欢迎光临!澳门在线网站大全,主营:山东燃气锅炉山东电采暖锅炉山东多介质过滤器和射线防护器材等。
  • 服务热线:18678809986
  • 首页 关于我们 产品中心 新闻中心 工程案例 设备选型 联系我们
  • 您的位置:首页> 新闻中心 >

    多孔介质过滤器的水处理工艺
    来源:澳门在线网站大全 发布时间:2021-05-12

    多介质过滤器是以成层状的无烟煤、砂、细碎的石榴石或其他材料为床层,一个典型的多介质过滤器。
    The multi-media filter is a typical multi-media filter whose bed is made of anthracite, sand, fine garnet or other materials.
    设备是压力式的,其原理是当原水自上而下通过滤料时,水中悬浮物由于吸附和机械阻流作用被滤层表面截留下来;当水流进滤层中间时,由于滤料层中的砂粒排列的更紧密,使水中微粒有更多的机会与砂粒碰撞,于是水中凝絮物、悬浮物和砂粒表面相互粘附,水中杂质截留在滤料层中,从而得到澄清的水质。经过滤后的出水悬浮物可在5毫克/升以下。
    The principle of the equipment is that when the raw water passes through the filter material from top to bottom, the suspended solids in the water will be intercepted by the surface of the filter layer due to adsorption and mechanical resistance; When the water flows into the middle of the filter layer, because the sand particles in the filter layer are arranged more closely, the particles in the water have more chances to collide with the sand particles, so the flocs, suspended solids and sand particles in the water adhere to each other, and the impurities in the water are trapped in the filter layer, so as to obtain the clarified water quality. The suspended solids in the filtered effluent can be less than 5 mg / L.
    特点
    characteristic
    1、多孔介质过滤器广泛用于水处理的工艺中,可以单独使用,但多数是作为水质深度处理的预过滤。
    1. Porous media filters are widely used in water treatment process, and can be used alone, but most of them are used as pre filtration for advanced water treatment.
    2、多介质过滤器是常用的水质深度净化的预处理装置,可根据工艺要求填加不同的滤料。
    2. Multi media filter is a common pretreatment device for deep purification of water quality, which can be filled with different filter materials according to the process requirements.
    山东多介质过滤器
    3、多介质过滤器材质可采用玻璃钢、A3钢防腐或衬胶、全不锈钢。操作方式有全自动和手动两种形式,自动控制是采用美国进口的自动控制器及气、液动阀控制,操作简便易于维护保养,在各行各业水处理工艺的前处理装置得到广泛的应用。
    3. The material of multi-media filter can be glass fiber reinforced plastic, A3 steel anti-corrosion or rubber lining, all stainless steel. There are two kinds of operation modes: automatic control and manual control. The automatic control is controlled by the automatic controller and pneumatic and hydraulic valves imported from the United States. It is easy to operate and maintain. It is widely used in the pretreatment devices of water treatment process in all walks of life.
    4、多介质过滤器的过滤材料应有足够的化学稳定性,各介质的相对密度和粒径应有一定差别,由无烟煤与石英砂组成的双层滤料过滤器所用的无烟煤相对密度为1.4—1.6,粒径为0.8—1.8mm,石英砂相对密度为2.6—2.65,粒径为0.5—1.2mm;3层滤料过滤器除了以上两种滤料外还可以用锰砂、磁铁矿之类的重质矿石,其相对密度为4.7—5.0,粒径为0.5—4mm。
    4. The filter material of multi-media filter should have enough chemical stability, and the relative density and particle size of each medium should be different. The relative density of anthracite used in the double-layer filter material composed of anthracite and quartz sand is 1.4-1.6, the particle size is 0.8-1.8mm, and the relative density of quartz sand is 2.6-2.65, the particle size is 0.5-1.2mm; In addition to the above two kinds of filter media, the three-layer filter media can also use heavy ores such as manganese sand and magnetite with relative density of 4.7-5.0 and particle size of 0.5-4mm.

    鲁公网安备 37011302000227号